+86 0371 8654 9132

replacing quarry dust by nigeria

An Innovative Method of Replacing River Sand by Quarry ...

quarry dust. as . replacement . for sand . has been su. p. por. t-ed in the pr. e. vious study (Manassa, 2010) [5] showing that up to 20% of sand has been effectively replaced by quarry dust in traditional concrete. Ilangovan et al. (2008) [9] reported that the strength of quarry rock dust concrete was comparably 10-12% more than that of

Partial Replacement of Sand by Quarry Dust in Concrete

Partial Replacement of Sand by Quarry Dust in Concrete Sumit L. Chauhan, Raju A.Bondre Assistant Professor P. I. G. C. E. Nagpur . Abstract- The paper describe the role of quarry dust In the construction of buildings and other structures to eliminate the demand of natural sand by using quarry waste to replace the use of natural sand.

ASSESSING QUARRY DUST AS A POSSIBLE REPLACEMENT OF

Abstract: This research was carried out to investigate the effect of replacing river sand with quarry dust. 45 numbers of 450 x 225 x 225 mm of hollow blocks with 0, 25, 50, 75 and 100% quarry dust replacement were produced and tested for compressive strength at 7, 14 and 28 days and also for density and water absorption at 28 days, respectively.

Use of Quarry Dust to Replace Sand in Concrete – An ...

For this concrete mix, quarry dust was added for replacement of sand from 0% to 100% in step of 10%. International Journal of Scientific and Research Publications, Volume 3, Issue 12, December 2013 2 ISSN 2250-3153 ijsrp.org B. Casting of specimen Mould of size 150 x 150 x 150 mm was used to cast specimens ...

AN EXPERIMENTIAL STUDY ON USE OF QUARRY DUST TO

Replacing quarry dust, can reduce the requirement of land fill area and can also solve the problem of natural scarcity of land. Sand is a very popular ingredient of concrete but day by day its availability is becoming an issue, and its availability at some places can also be an issue. ...

Introduction to Quarry-Dust as Partial Replacement ...

May 19, 2020 · Introduction to Quarry-Dust as Partial Replacement Material to Scarce Building Material - written by Madhavi Sakhare , S. Nazma , G. S Harish Kumar published on 2020/05/19 download full article with reference data and citations

Use of Crushed Granite Fine as Replacement to River Sand ...

In India the use of quarry dust to replace river sand was reported by [2]. The use of rock dust as an alternative to natural sand was also reported by [5]. The use of up to 20% quarry waste fine as a partial replacement for natural sand in the production of concrete, in Malaysia was also reported [6].

An Experimental study on uses of Quarry Dust to replace ...

The suitability of quarry dust as a sand replacement material shows that the mechanical properties are improved and also elastic modulus. The compressive strength achieved optimum by replacing fine aggregate with quarry dust in ratio of 60 : 40 as done by Hmaid Mir [1]. Felekoglu et al. [2] observed that the incorporation of ...

EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL

to study the effect of partial replacement of fine aggregates by quarry dust and cement by fly ash on cement concrete. 1.2 NEED FOR INVESTIGATION Quarry Dust These residues are generally less than 1% aggregate production in the normal concrete. The introduction of quarry dust for mixing is limited due to its high fineness.

Quarry Dust Uses in a Construction Project

Jun 06, 2016 · Quarry dust uses is not limited to highway projects, in construction projects that involves homes building, it is fast becoming popular too. Partial replacement of sand with quarry dust will make good concrete that is well desired in residential construction. The final product is strong bricks, slabs or tiles that are produced at lower cost ...

S.K. Singh L.N Malviya

In present study, quarry dust is used as replacement of sand in sandcrete. The amount of quarry dust is varied and its effect is observed on water absorption, density and compressive strength. ... Minna, Nigeria [1], the compressive strength was though found to be below the Nigerian standards, but lower quality was apparently due to workmanship.

OPTIMIZING COMPRESSIVE STRENGTH CHARACTERISTICS OF

A range of 0%, 10%, 15%, 20% and 25% sand replacement with quarry dust15%, 20% and 25% sand replacement with quarry dust was used in was used in the cement:the cement: sand mix ratios of 1:6 and 1:8 for molding the blosand mix ratios of 1:6 and 1:8 for molding the bloccks of size 450mm x 225mm x 225mm.These blocks ks of size 450mm x 225mm x ...

EFFECT OF PARTIAL REPLACEMENT OF SAND WITH QUARRY DUST

This work investigated the effect of partial replacement of sand with quarry dust on the compressive strength, flexural strength, split tensile strength and water absorption of sandcrete blocks. River sand was replaced with quarry dust at percentages ranging from 0 to 40 at cement/combined aggregate ratio of 1: 6. The blocks were moulded using a Rosa Commetta block laying machine and were ...

is one of the important

with increase in percentage replacement of natural river sand with quarry dust especially from 50% and thereafter with constant water cement ratio (w/c) as shown in above. At 50% quarry dust has lesser slump, this shows that quarry dust requires more w/c ratio than river sand to make it workable. Figure 3: Concrete Workability (Compaction

Partial Replacement of Fine Aggregates with Quarry Dust ...

river sand. Quarry dust and Marble powder contains similar properties as that of river sand and hence accepted as a building material. The present paper focuses on investigating maximum percentage replacement of river sand by Quarry dust and Marble powder in varying equal percentages 0%, 10%, 20%, 30%, 40%, 50%, and 60% for M25 mix designations.

Analysis of Concrete Made from Quarry Dust

replacement of 5%, 15% and 20% at 10% have increments, and 14, 28 days have decreased with replacement of 5%, 15% to 20% and increase at 10%, ... Quarry dust is a byproduct that is generated from the crushing plants and which is abundantly available to an extent of millions of tons per year associated with disposal problems

IOP Conference Series: Materials Science and Engineering ...

grades of concrete by replacement of sand with quarry dust. Key Words: Concrete, Compressive strength, Quarry Dust, Replacement, Sand. 1. INTRODUCTION Quarry dust, is a by-product releases from the cutting and crushing process of stone which is a concentrated material to use as fine aggregates. By exploding mountain, rock will be crushed to

Experimental Investigation on Quarry Dust as a Partial ...

quarry dust replacement is about 45%. 3. Maximum split tensile strength was observed when quarry dust replacement is about 45%. 4. Maximum flexural strength was observed when quarry dust replacement is about 45%. REFERENCES [[1] N N Priya Darshini*, D Rambabu (2019): An Experimental Study On The Use Of Quarry Dust As A ...

Study on Compressive Strength of Quarry Dust as Fine ...

Jul 28, 2016 · The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced and can also solve the problem of natural sand scarcity. The availability of sand at low cost as a fine aggregate in concrete is not suitable and ...

Studies on quarry dust as partial replacement of fine ...

May 05, 2017 · Quarry dust can be used as an economic alternative to the natural sand. In this investigation an attempt is made to utilize quarry dust as a partial substitute for natural sand in producing concrete. Natural sand is replaced by Quarry dust at an interval of 5%, 10%, 15%, 20% and 25%. Mix proportions for M20 concrete is prepared with reference ...

Optimization of Concrete Made with Abakaliki Quarry Dust ...

In recent years, Nigeria has witness rapid development especially in the area of infrastructural development like roads, bridges, buildings etc. The conventional methods used in concrete mixing have its own peculiar problems, like time wasting, material wasting and errors. These problems have been the cause of structural failures which has given rise to loss of life and properties.

Experimental Study on Concrete and Cement Plaster Using ...

quarry dust along with 1% dosage of super plasticizer increase in the compressive strength is around 85%. Chandana Sukesh et al (2013) presented the paper on partial replacement of sand with quarry dust in concrete. This present work is an attempt to use Quarry Dust as partial replacement for Sand in concrete. Attempts have been made

Study of Sand Crete Blocks by International Journal for ...

Apr 12, 2017 · In case of both 7 days and 28 days strength, there is decreasing trend in compressive strength but the decrement is only significant after about 60% replacement of

LAUJOCES

Effects of Partial Replacement of Fine Aggregate with Quarry Dust on Concrete Properties 1 Ajamu S. O., 2 Raheem I. A., 1 Attah S. B. and 1 Onicha J. O. 1 Department of Civil Engineering, Ladoke Akintola University of Technology PMB 4000 Ogbomoso Oyo State Nigeria, 2 Department of Civil Engineering, Kwara State University Malete Kwara State Nigeria ...

Ternary and quaternary blends as partial replacement of ...

Organisation of Nigeria [19]. However, durability tests are required to ascertain their suitability, which is scarce in literature. Hollow blocks which met the minimum CS requirements were constructed with com-bination of 70% quarry dust and 30% laterite as complete sand replacement, 100% quarry dust and crumb rubber (CR) as fine aggregate

Investigation on Mechanical Properties of Lightweight ...

Jul 08, 2019 · Optimum utilization of quarry dust as partial replacement of sand in concrete. International Journal of Applied Science and Engineering Research. ... Nigeria. [15] Paramasivam, P., Loke, Y.O. (1980). ... High-strength rice husk ash concrete incorporating quarry dust as a partial substitute for sand. Construction and Building Materials, 25(7 ...

Civil Engineering - University of Nigeria, Nsukka Open ...

Jun 07, 2018 · the effect of partial replacement of cement with quarry dust on the compressive strength of grades 20 and 25 concrete. by nnamani obinna anthony. the effect of partial replacement of cement with quarry dust on the compressive strength of grades 20 and 25 concrete

Analysis of Concrete Made from Quarry Dust

replacement of 5%, 15% and 20% at 10% have increments, and 14, 28 days have decreased with replacement of 5%, 15% to 20% and increase at 10%, ... Quarry dust is a byproduct that is generated from the crushing plants and which is abundantly available to an extent of millions of tons per year associated with disposal problems

(PDF) EFFECT OF QUARRY DUST AS PARTIAL REPLACEMENT OF

Results showed that by replacing 50% of fine aggregate with quarry dust, concrete of maximum compressive strength can be produced as compared to all other replacement levels. The effect of quarry ...

EXPERIMENTAL STUDY ON REPLACEMENT OF FINE

110 Int. J. Struct. & Civil Engg. Res. 2014 Kumar S et al., 2014 EXPERIMENTAL STUDY ON REPLACEMENT OF FINE AGGREGATE BY QUARRY DUST IN CONCRETE Vijay P Gowda1, Dinesh1, Kiran muchandi1, Avinash1 and Kumar S1* The reduction in the sources of natural sand and the requirement for reduction in the cost of

Behavior of Concrete with Agro and Industry Waste as a ...

cube and cylinder 10% replacement of cement by GSA in quarry dust concrete 50% replace for sand, is little better than control concrete as it can be observed from test results of table 5 and 6. Fig.4 Specimen for Compressive Strength of Cubes Fig.5 Failure of compressive cube

[PDF] Improved Concrete Properties Using Quarry Dust as ...

DOI: 10.6084/M9.FIGSHARE.1372347.V1 Corpus ID: 12347722. Improved Concrete Properties Using Quarry Dust as Replacement for Natural Sand @inproceedings{Ijerd2015ImprovedCP, title={Improved Concrete Properties Using Quarry Dust as Replacement for Natural Sand}, author={Ijerd and Hamid Mir Anzar}, year={2015} }

Partial replacement of wood ash and quarry dust with ...

Nov 10, 2014 · ABSORPTION TEST Table 10: Quarry dust Concrete Absorption test values Sl .no % QD replaced Initial wt. (W1) Final wt. (W2) % absorption 0 0 8.62 8.635 0.17 10 10 8.175 8.19 0.183 15 15 8.18 8.245 0.79 30 30 8.185 8.425 2.93 45 45 8.255 8.57 3.81 X. RESULTS AND DISCUSSION Based on grain size analysis and Blain air permeability test, it has been ...

Strength and consistency behaviour of Member, Research ...

was synthesized with quarry dust (QD) and activator materials (Sodium Hydroxide (NaOH) and Sodium Silicate (Na 2 SiO 3)). Based on previous findings on the synthesis of GPCs [28, 29, 31, 42-47], the quarry dust based Geopolymer was synthesized. 2.2 Experimental methods The conventional tests that were conducted on the test soil

(PDF) EVALUATION OF COMPRESSIVE STRENGTH OF CONCRETE

quarry dust as par tial replacement of fine aggregate; sand, in concrete production. Quarry dust was used t o replace fine aggregates from 0% to 40% in steps of 10%.

fly ash and quarry dust concrete - BINQ Mining

Jan 29, 2013 · Cement production using fly ash and Quarry Dust – Gold Ore . Concrete is the most popular building material in the world. However, the production of cement has diminished the limestone reserves in the world and requires a great »More detailed

Structural Properties of Laterite - Quarry Dust Cement Blocks

Jul 10, 2017 · Sandcrete blocks are still extensively used as masonry units in Nigeria and given the upsurge in the number of block production industries in Calabar and other parts of the country, utilizing quarry dust, laterite and other fine aggregates as partial or full replacement for natural sand, it is, therefore, not out of place to ensure that the ...